British Airships, Past, Present, and Future Part 6

No. 17 (Beta) also saw active service, as she was based for a short period early in 1915 at Dunkirk, and was employed in spotting duties with the Belgian artillery near Ostend.

The Gamma and the Delta were both lying deflated at Farnborough at the outbreak of the war, and in the case of the latter the car was found to be beyond repair, and she was accordingly deleted. The Gamma was inflated in January, 1915, and was used for mooring experiments.

The Eta, having been inflated and deflated several times owing to the poor quality of the envelope, attempted to fly to Dunkirk in November, 1914. She encountered a snowstorm near Redhill and was compelled to make a forced landing. In doing this she was so badly damaged as to be incapable of repair, and at a later date was deleted.

No. 8, which was delivered towards the end of 1914, was also moored out in the open for a short time near Dunkirk, and carried out patrol in the war zone of the Belgian coast.

So ends the story of the Naval Airs.h.i.+p Service before the war.

With the submarine campaign ruthlessly waged by the Germans from the spring of 1915 and onwards, came the airs.h.i.+p's opportunity, and the authorities grasped the fact that, with development, here was the weapon to defeat the most dangerous enemy of the Empire. The method of development and the success attending it the following chapters will show.

CHAPTER VI

NAVAL AIRs.h.i.+PS.--THE NON-RIGIDS--S.S. TYPE

The development of the British airs.h.i.+ps of to-day may be said to date from February 28th, 1915. On that day approval was given for the construction of the original S.S. airs.h.i.+p.

At this time the Germans had embarked upon their submarine campaign, realizing, with the failure of their great a.s.saults on the British troops in Flanders, that their main hope of victory lay in starving Great Britain into surrender. There is no doubt that the wholesale sinking of our merchant s.h.i.+pping was sufficient to cause grave alarm, and the authorities were much concerned to devise means of minimizing, even if they could not completely eliminate the danger. One proposal which was adopted, and which chiefly concerns the interests of this book, was the establishment of airs.h.i.+p stations round the coasts of Great Britain. These stations were to be equipped with airs.h.i.+ps capable of patrolling the main s.h.i.+pping routes, whose functions were to search for submarines and mines and to escort s.h.i.+pping through the danger zones in conjunction with surface craft.

Airs.h.i.+p construction in this country at the time was, practically speaking, non-existent. There was no time to be wasted in carrying out long and expensive experiments, for the demand for airs.h.i.+ps which could fulfil these requirements was terribly urgent, and speed of construction was of primary importance. The non-rigid design having been selected for simplicity in construction, the expedient was tried of slinging the fuselage of an ordinary B.E. 2C aeroplane, minus the wings, rudder and elevators and one or two other minor fittings, beneath an envelope with tangential suspensions, as considerable experience had been gained already in a design of this type.

For this purpose the envelope of airs.h.i.+p No. 2, which was lying deflated in the shed at Farnborough, was rushed post haste to Kingsnorth, inflated and rigged to the fuselage prepared for it. The work was completed with such despatch that the airs.h.i.+p carried out her trial flight in less than a fortnight from approval being granted to the scheme. The trials were in every way most satisfactory, and a large number of s.h.i.+ps of this design was ordered immediately. At the same time two private firms were invited to submit designs of their own to fulfil the Admiralty requirements. One firm's design, S.S. 2, did not fulfil the conditions laid down and was put out of commission; the other, designed by Messrs. Armstrong, was sufficiently successful for them to receive further orders. In addition to these a car was designed by Messrs. Airs.h.i.+ps Ltd., which somewhat resembled a Maurice Farman aeroplane body, and as it appeared to be suitable for the purpose, a certain number of these was also ordered.

About this period the station at Farnborough was abandoned by the Naval Airs.h.i.+p Service to make room for the expansion of the military aeroplane squadrons. The personnel and airs.h.i.+ps were transferred to Kingsnorth, which became the airs.h.i.+p headquarters.

The greatest energy was displayed in preparing the new stations, which were selected as bases for the airs.h.i.+ps building for this anti-submarine patrol. Small sheds, composed of wood, were erected with almost incredible rapidity, additional personnel was recruited, stores were collected, huts built for their accommodation and that of the men, and by the end of the summer the organization was so complete that operations were enabled to commence.

The S.S., or submarine scout, airs.h.i.+p proved itself a great success.

Beginning originally with a small programme the type pa.s.sed through various developments until, at the conclusion of the war, no fewer than 150 s.h.i.+ps of various kinds had been constructed. The alterations which took place and the improvements effected thereby will be considered at some length in the following pages.

S.S.B.E. 2C

The envelope of the experimental s.h.i.+p S.S. 1 was only of 20,500 cubic feet capacity; for the active-service s.h.i.+ps, envelopes of similar shape of 60,000 cubic feet capacity were built. The shape was streamline, that is to say, somewhat blunt at the nose and tapering towards the tail, the total length being 143 feet 6 inches, with a maximum diameter of 27 feet 9 inches.

The gross lift of these s.h.i.+ps with 98% pure gas at a temperature of 60 degrees Fahrenheit and barometer 30 inches, is 4,180 lb. The net lift available for crew, fuel, ballast, armament, etc., 1,434 lb., and the disposable lift still remaining with crew of two on board and full tanks, 659 lb.

The theoretical endurance at full speed as regards petrol consumption is a little over 8 hours, but in practice it is probable that the oil would run short before this time had been reached. At cruising speed, running the engine at 1,250 revolutions, the consumption is at the rate of 3.6 gallons per hour, which corresponds to an endurance of 16 1/2 hours.

With the engine running at 1,800 revolutions, a speed of 50.6 miles per hour has been reached by one of these s.h.i.+ps, but actually very few attained a greater speed than 40 miles per hour.

The envelopes of S.S. airs.h.i.+ps are composed of rubber-proofed fabric, two fabrics being used with rubber interposed between and also on the inner or gas surface. To render them completely gastight and as impervious to the action of the weather, sun, etc., as possible, five coats of dope are applied externally, two coats of Delta dope, two of aluminium dope and one of aluminium varnish applied in that order.

One ripping panel is fitted, which is situated on the top of the envelope towards the nose. It has a length of 14 feet 5 inches and a breadth of about 8 inches. The actual fabric which has to be torn away overlaps the edge of the opening on each side. This overlap is sewn and taped on to the envelope and forms a seam as strong and gastight as any other portion of the envelope. Stuck on this fabric is a length of biased fabric 8 1/4 inches wide. These two strips overlap the opening at the forward end by about three feet. At this end the two strips are loose and have a toggle inserted at the end to which the ripping cord is tied. The ripping cord is operated from the car. It is led aft from the ripping panel to a pulley fixed centrally over the centre of the car, from the pulley the cord pa.s.ses round the side of the envelope and through a gland immediately below the pulley.

The nose of the envelope is stiffened to prevent it blowing in. For this purpose 24 canes are fitted in fabric pockets around the nose and meet at a point 2 1/4 inches in front of the nose. An aluminium conical cap is fitted over the canes and a fabric nose cap over the whole.

Two ballonets are provided, one forward and one aft, the capacity of each being 6,375 cubic feet. The supply of air for filling these is taken from the propeller draught by a slanting aluminium tube to the underside of the envelope, where it meets a longitudinal fabric hose which connects the two ballonet air inlets. Non-return fabric valves known as crab-pots are fitted in this fabric hose on either side of their junction with the air scoop. Two automatic air valves are fitted to the underside of the envelope, one for each ballonet. The air pressure tends to open the valve instead of keeping it shut and to counteract this the spring of the valve is inside the envelope. The springs are set to open at a pressure of 25 to 28 mm.

Two gas valves are also fitted, one on the top of the envelope, the other at the bottom. The bottom gas valve spring is set to open at 30 to 35 mm. pressure, the top valve is hand controlled only.

These valves are all very similar in design. They consist of two wooden rings, between which the envelope is gripped, and which are secured to each other by studs and b.u.t.terfly nuts. The valve disc, or moving portion of the valve, is made of aluminium and takes a seating on a thin india rubber ring stretched between a metal rod bent into a circle of smaller diameter than the valve opening and the wooden ring of the valve. When it pa.s.ses over the wooden ring it is in contact with the envelope fabric and makes the junction gastight. The disc is held against the rubber by a compressed spring.

The valve cords are led to the pilot's seat through eyes attached to the envelope.

The system of rigging or car suspension is simplicity itself and is tangential to the envelope. On either side there are six main suspensions of 25 cwt. stranded steel cable known as "C" suspensions.

Each "C" cable branches into two halves known as the "B" bridles, which in turn are supported at each end by the bridles known as "A." The ends of the "A" bridles are attached to the envelope by means of Eta patches. These consist of a metal D-shaped fitting round which the rigging is spliced and through which a number of webbing bands are pa.s.sed which are spread out fanwise and solutioned to the envelope. It will thus be seen that the total load on each main suspension is proportionally taken up by each of the four "A" bridles, and that the whole weight of the car is equally distributed over the greater part of the length of the envelope. Four handling guys for manoeuvering the s.h.i.+p on the ground are provided under the bow and under the stem. A group of four Eta patches are placed close together, which form the point of attachment for two guys in each case. The forward of these groups of Eta patches forms the anchoring point. The bridle, consisting of 25 cwt. steel cable, is attached here and connected to the forepart of the skids of the car. The junction of this bridle with the two cables from the skids forms the mooring point and there the main trail rope is attached. This is 120 feet long and composed of 2-inch manilla. This is attached, properly coiled, to the side of the car and is dropped by a release gear. It is so designed that when the airs.h.i.+p is held in a wind by the trail rope the strain is evenly divided between the envelope and the car. The grapnel carried is fitted to a short length of rope. The other end of the rope has an eye, and is fitted to slide down the main trail rope and catch on a knot at the end.

For steering and stabilizing purposes the S.S. airs.h.i.+p was originally designed with four fins and rudders, which were to be set exactly radial to the envelope. In some cases the two lower fins and rudders were abandoned, and a single vertical fin and rudder fitted centrally under the envelope were subst.i.tuted. The three planes are identical in size and measure 16 feet by 8 feet 6 inches, having a gross stabilizing area of 402 1/2 square feet.

They are composed of spruce and aluminium and steel tubing braced with wire and covered by linen doped and varnished when in position.

The original rudders measured 3 feet by 8 feet 6 inches. In the case, however, of the single plane being fitted, 4-feet rudders are invariably employed. Two kingposts of steel tube are fitted to each plane and braced with wire to stiffen the whole structure.

The planes are attached to the envelope by means of skids and stay wires. The skids, composed of spruce, are fastened to the envelope by eight lacing patches.

The car, it will be remembered, is a B.E. 2C fuselage stripped of its wings, rudders and elevators, with certain other fittings added to render it suitable for airs.h.i.+p work. The undercarriage is formed of two ash skids, each supported by three struts. The aeroplane landing wheels, axle and suspensions are abandoned.

In the forward end of the fuselage was installed a 75 horse-power air cooled Renault engine driving a single four-bladed tractor propeller through a reduction gear of 2 to 1. The engine is of the 8-cylinder V type, weighing 438 lb. with a bore of 96 mm. and a stroke of 120 mm.

The Claudel-Hobson type of carburettor is employed with this engine.

The type of magneto used is the Bosch D.V.4, there being one magneto for each line of cylinders. In the older French Renaults the Bosch H.L.8 is used, one magneto supplying the current to all the plugs.

Petrol is carried in three tanks, a gravity and intermediate tank as fitted to the original aeroplane, and a bottom tank placed underneath the front seat of the car. The petrol is forced by air pressure from the two lower tanks into the gravity tank and is obtained by a hand pump fitted outside the car alongside the pilot's seat. The oil tank is fitted inside the car in front of the observer.

The observer's seat is fitted abaft the engine and the pilot's seat is aft of the observer. The observer, who is also the wireless operator, has the wireless apparatus fitted about his seat. This consists of a receiver and transmitter fitted inside the car, which derives power from acc.u.mulator batteries. The aerial reel is fitted outside the car.

During patrols signals can be sent and received up to and between 50 and 60 miles.

The pilot is responsible for the steering and the running of the engine, and the controls utilized are the fittings supplied with the aeroplane. Steering is operated by the feet and elevating by a vertical wheel mounted in a fore and aft direction across the seat.

The control wires are led aft inside the fairing of the fuselage to the extreme end, whence they pa.s.s to the elevators and rudders.

The instrument board is mounted in front of the pilot. The instruments comprise a watch, an air-speed indicator graduated in knots, an aneroid reading to 10,000 feet, an Elliott revolution counter, a Clift inclinometer reading up to 20 degrees depression or elevation, a map case with celluloid front.

There are in addition an oil pressure gauge, a petrol pressure gauge, a gla.s.s petrol level and two concentric gla.s.s pressure gauges for gas pressure.

The steering compa.s.s is mounted on a small wooden pedestal on the floor between the pilot's legs.

The water-ballast tank is situated immediately behind the pilot's seat and contains 14 gallons of water weighing 140 lbs. The armament consists of a Lewis gun and bombs. The bombs are carried in frames suspended about the centre of the undercarriage. The bomb sight is fitted near the bomb releasing gear outside the car on the starboard side adjacent to the pilot's seat. The Lewis gun, although not always carried on the early S.S. airs.h.i.+ps, was mounted on a post alongside the pilot's seat.

S.S. MAURICE FARMAN

For this type of S.S. the cars were built by Messrs. Airs.h.i.+ps Ltd. In general appearance they resemble the Maurice Farman aeroplane and were of the pusher type; 60,000 and in later cases 70,000 cubic feet envelopes were rigged to these s.h.i.+ps, which proved to be slightly slower than the B.E. 2C type, but this was compensated for owing to the increased comfort provided for the crew, the cars being more roomy and suitable for airs.h.i.+p work in every way.

The system of rigging to all intents and purposes is the same in all types of S.S. s.h.i.+ps, the suspensions being adjusted to suit the different makes of car.

In these s.h.i.+ps the pilot sits in front, and behind him is the wireless telegraphy operator; in several cases a third seat was fitted to accommodate a pa.s.senger or engineer; dual rudder and elevator controls are provided for the pilot and observer.

The engine is mounted aft, driving a four-bladed pusher propeller, with the petrol tanks situated in front feeding the carburettors by gravity.