Atlantic Narratives Part 28

'Loader? New man?'

I nodded.

'Then come along with me.'

He was a tall, thin man, who walked with his head thrown forward and his chin against his chest as if in constant fear of striking the low beams overhead. I followed him, stumbling rather clumsily over the broken coal beside the track. The train had come to a stop over the pit between the rails, and men with iron bars were beating loose the frogs and releasing the hopper-bottoms of the cars. Heavy clouds of fine coal-dust poured up from the cars as the coal roared down into the bins; and the clanking of metal, the crash of falling coal, and the unintelligible shouting of the foreigners, filled the entry with a dull tumult of sounds.

Dodging the low trolley-wire which hung about five feet above the rails, we crawled across the coupling between two of the cars to the other side of the entry, and walked to the left, past the locomotive where the motorman was still sitting in his low seat, waiting to pull out his train of empty cars into the sudden darkness of the tunnel beyond. Then, for the first time, I learned that mines are echoless, and that sound--like light--is absorbed by the blotter-like walls of the tunnels.

We walked down the entry between the rails, and after a hundred yards turned with the switch in the track sharply to the right, and again on.

Sense of direction or angles was lost, and, like the faces in a foreign race of people, where one can see little or no individuality, so here, each corner seemed the same, and in a hundred yards I was utterly lost.

Above was the smooth, black roof; below, the ties and the rails; and on either side, behind the two long rows of props, the face of the coal-seam, which glittered and sparkled in the light from our pit-lamps like a dull diamond.

We talked a little. My companion asked me where I had worked before, how much I knew of mines, and a few other questions; and still we walked on, dodging the low wire that comes level with one's ear, and stumbling over the layer of broken coal that lay strewn here and there between the rails.

The silence was like the darkness--a total absence of sound, rather than stillness, as my first impression of the mine had been that of an absence of light, rather than of darkness. The smoking lights in our caps seemed to press out through the blackness twenty feet around us, where the light disappeared and was gone. And always in front of us, out of the black darkness, the two long lines of props on either side of the track stepped one by one into the yellow haze of light and sank again into darkness behind us as we walked.

The air was cool and damp, but as we turned the last corner, the dampness seemed suddenly gone from it. It was warmer and closer. Here the track swerved up from one of the main tunnels into a 'room'; and at the end, or 'heading' of this room, which we reached a few minutes later, empty and waiting for its first load, stood one of the square cars which I had seen before at the mine-bottom and which we pa.s.sed several times on sidings by the track. The car was pushed up to the end of the track and its wheels 'spragged' by two blocks of coal. Here the tunnel suddenly ended, and from the blank back 'face' a rough, broken pile of coal streamed down on both sides of the car and reared up before it against the roof.

'Just shovel 'er full, then wait till the motor takes her out and sends in an empty, and fill that one. I'll look in on you once in a while and see how you're getting along.'

Then he turned and walked down the track and left me in the dim light of my single pit-lamp.

II

In the first days of coal-mining--as in many mines to-day where modern methods have not superseded those of old-time miners--a man did all the work. With his hand-drill he bored into the face of the coal at the head of his room, or entry, and from his keg of powder he made long cartridges and inserted them into his drill-holes. Then, when the coal was blasted down, and he had broken it with a pick, he loaded it with his shovel into a car; and tr.i.m.m.i.n.g square the face of the tunnel, propping when necessary, he pushed on and on until he broke through and joined the next tunnel or completed the required length of that single entry.

But to-day these conditions are, in most instances, changed. The work begins with the 'machine-men,' who operate the 'chain-machines.' In order that the blast may dislodge by gravity an even block of coal, of the dimensions of the cross-section of the tunnel, these men cut with their machines a 'sump-cut,' or, in other words, carve out an opening level with the floor, about six inches high and six feet deep, at the end of the tunnel. The machines--which are propelled by electricity--consist of a motor and a large oblong disk, about which travels an endless chain containing sharp steel 'bits' or picks. The machine is braced, the current turned on, and the disk advanced against the coal, automatically advancing as the bits grind out the coal. As soon as the machine has entered to the full six feet, the disk is withdrawn and the cut continued until it extends across the entire face.

In the evening the drillers, with their powerful air-drills, bore a series of five or six six-foot 'shot-holes,' four along the roof, and two on each side for the 'rib-shots.' Then a third crew of men, the 'shot-firers,' fill the deep drill-hole with long cartridges of coa.r.s.e black powder, and blast down the coal, which falls broken and crumbled into the cut prepared by the machine-men. In the morning, when the ever-moving current of air, forced into the mine by the fan at the mouth of the air-shaft, has cleared away the dust and smoke, the loaders enter the mine, and all day long load into the ever-ready cars the coal that has been blasted down, until the 'place' is cleaned up, and their work is done. Then they move on to another 'place'; and so the work goes on in a perfect system of rotation.

My companion had told me, as we walked from the mine-bottom, that his name was Billy Wild. 'Call me Billy,' he said; and as we walked down the track to the main entry, he turned and called over his shoulder, 'You're in Room 27, third west-south. That's where you are, if you want to know.'

The light in my lamp was burning low, and I sat down on a pile of coal beside the track, lifted it out of the socket in my cap, and pried up the wick with a nail which one of the men 'on top' had given me for the purpose. Then I stripped to the waist and began to load, shovelful after shovelful, each lifted four feet and turned over into the waiting car, for two long hours, sometimes stopping to break with my pick great blocks of coal that were too large to lift, even with my hands. Then, finally, lumps of coal began to show above the edge of the car, and I 'trimmed' it, lifting some of the larger pieces to my knees, then against my chest, and then throwing them up on the top of the pile.

The noise of the shovel sc.r.a.ping against the floor and the clatter of the coal as the great pile slid down and filled each hole that I dug out at its foot, filled the tunnel with friendly sounds; but when the car was loaded and I slipped on my coat and sat down on a pile of fine coal-dust beside the track to wait, silence suddenly submerged me. I could hear my heart beat, and curious noises sang in my ears. Up in the roof, under the stratum of slate above the coal, came a trickling sound like running water--the sound of gas seeping out through the crevices in the coal. I was wet with sweat, and my face, hands, and body were black where the great cloud of dust which my shovel had created had smeared my wet skin. Dull pains in the small of my back caught me when I moved, and every muscle in my body ached. (In a week my hands had blistered, the blisters had broken, and over the cracked flesh ingrained with coal-dust healing callouses had begun to form.)

Then, far off in the distance, came a m.u.f.fled, grinding sound that grew louder and louder--a sound that almost terrified. A dull, yellow light, far down in the mouth of the room, outlined the square of the tunnel; and then, around the corner came the headlight of the electric 'gathering' or switching locomotive, and above it, the bobbing yellow flames of two pit-lamps. With a grinding roar, the motor struck the upgrade and came looming up the tunnel, filling it with its bulk. There was sound, and the silence was gone. The coupling of the locomotive locked with the coupling of the waiting car, and they rumbled away.

Once more the locomotive came, this time with an 'empty' to be filled.

In the old days, mules were used to 'gather' the loaded cars, and, in fact, are still employed in most mines to-day; but electricity permits bigger loads, and the dozen or two of mules that lived in the mine were used only where it was impossible to run the locomotives.

At the end of the week I was given a companion, or 'buddy.' Our lockers in the wash-house were near together, and we usually went down on the same hoist; but some mornings I would find Jim ahead of me, waiting by the scale-house. Jim rarely took the full benefit of the wash-house privileges, and morning found him with the dirt and grime of the work of the previous day still on his face. He was a Greek, short, with a thin, black moustache, which drooped down into two 'rat-tail' points. Around each eye a heavy black line of coal-dust was penciled, as though by an actor's crayon. His torn black working clothes, greasy with oil dripped from his pit-lamp, hung on him like rags on a scarecrow.

From the scale-house we walked up the now familiar entries in 'third west-south' to the room where we worked, and dug out our picks and shovels from under a pile of coal where we had hidden them the night before. Then, in the still, close air of the silent room, we began each morning to fill the first car.

Down in the scale-house, where the cars were hauled over the scales set in the track, before being dumped into the bins between the rails, Old Man Davis took the weights; and when the loader's number--a small bra.s.s tag with his number stamped upon it--was given to him, he marked down opposite it the pounds of coal to the loader's credit; and so each day on the great sheet, smooched with his dusty hands, stood a record of each man's strength measured in tons of coal.

When Jim and I worked together, we took turns hanging our numbers inside the car; and each night we remembered to whose credit the last car had been; and the next morning, if my number had been hung in the last car of the day before, Jim would pull one of his tags out of his pocket and hang it on the hook just inside the edge of the empty car. Then, he on one side and I on the other, we worked, shovelful after shovelful, until the coal showed above the edge. And then came the 'tr.i.m.m.i.n.g' with the great blocks that had to be lifted and pushed with our chests and arms up on the top of the filled car.

Time went slowly then, for we could load a car together in less than an hour; and sometimes it took an hour and a half before the 'gathering'

motor would come grinding up into the room to give us an 'empty.' In those long half-hours we would sit together on a pile of coal-dust beside the track and try to talk to each other.

Jim was a Greek, and from what I was able to gather, he came from somewhere in the southern part of the peninsula. I remembered a little Homer, and I often tried stray words on him; but my p.r.o.nunciation of the Greek of ancient Athens was not the Greek of Jim Bardas; and although he recognized attempts at his own tongue and oftentimes the meaning of the words, it was not until we discovered a system of writing that we began to get along. Mixed in with the coal that had been blasted down by the shot-firers the night before, we occasionally found strips of white paper from the cartridges. We always saved these and laid them beside our dinner-pails; and when the car was filled and we had sat down again in the quiet beside the track, we would take our pit-lamps out of our caps and, rubbing our fingers in the greasy gum of oil and coal-dust that formed under the lamp-spout, we would write Greek words with our fingers on the white strips of paper.

Jim knew some English: the word for coal, car, loader--and he learned that my name was Joe, and called me 'My friend,' and 'buddie.' Then sometimes, after the fascination of writing words had worn away, we would sit still and listen to the gas or for the approach of the motor; and sometimes, when the wicks in our lamps had burned low, I would take out of my pocket the round ball of lamp-wick, and, like old women with a skein of yarn, we would wind back and forth, from his fingers to my own, sixteen strands of lamp-wick; and then, tying the end in a rude knot and breaking it off, stick the skein of wick down the spout of the lamp until only the end remained in sight. Next, lifting the little lid on the top, we would fill the body with oil, shaking it until the wick was thoroughly soaked so that it would burn.

III

To the ear accustomed to the constant sound of a living world, the stillness of a coal-mine, where the miles of cross-cuts and entries and the unyielding walls swallow up all sounds and echo, is a silence that is complete; but, as one becomes accustomed to the silence through long hours of solitary work, sounds become audible that would escape an ear less trained. The trickling murmur of the gas; the spattering fall of a lump of coal, loosened by some mysterious force from a cranny in the wall; the sudden knocking and breaking of a stratum far up in the rock above; or the scurry of a rat off somewhere in the darkness--strike on the ear loud and startlingly. The eye, too, becomes trained to penetrate the darkness; but the darkness is so complete that there is a limit, the limit of the rays cast by the pit-lamp.

There is a curious thing that I have noticed, and as I have never heard it mentioned by any of the other men, perhaps it is an idea peculiar to myself; but on days when I entered the mine, with the strong yellow sunlight and the blue sky as a last memory of the world above, I carried with me a condition of fair weather that seemed to penetrate down into the blackness of the entries and make my pit-lamp burn a little more brightly. On days when we entered the mine with a gray sky above, or with a cold rain beating in our faces, there was a depression of spirits that made the blackness more dense and unyielding, and the lights from the lamps seemed less cheerful.

Sometimes the roof was bad in the rooms, and I soon learned from the older miners to enter my room each morning testing gingerly with my pit-lamp for the presence of gas, and reaching far up with my pick, tapping on the smooth stone roof to test its strength. If the steel rang clean against the stone, the roof was good; but if it sounded dull and drummy, it might be dangerous. Sometimes, when the roof was weak, we would call for the section boss and prop up the loosened stone; but more often, the men ran their risk. We worked so many days in safety that it seemed strange that death could come; and when it did come, it came so suddenly that there was a surprise, and the next day we began to forget.

I had heard much of the dangers that the miner is exposed to, but little has been said of the risks to which the men through carelessness subject themselves. Death comes frequently to the coal-miners from a 'blown-out shot.' When the blast is inserted in the drill-hole, several dummy cartridges are packed in for tamping. If these are properly made and tamped, the force of the explosion will tear down the coal properly; but if the man has been careless in his work, the tamps will blow out like shot from a gun-barrel, and igniting such gas or coal-dust as may be present, kill or badly burn the shot-firers. The proper tamping is wet clay, but it is impossible to convince the men of it, and nine out of ten will tamp their holes with dummies filled with coal-dust (itself a dangerous explosive) scooped up from the side of the track. Again, powder-kegs are sometimes opened in a manner which seems almost the act of an insane man. Rather than take the trouble to unscrew the cap in the head of the tin powder-keg and pour out the powder through its natural opening, the miner will drive his pick through the head of the keg and pour the powder from the jagged square hole he has punched. And these are but two of the many voluntary dangers which a little care on the part of the men themselves would obviate.

A mine always seems more or less populated when the day-s.h.i.+ft is down; for during the hours of the working day, in every far corner, at the head of every entry and room, there are men drilling, loading, and ever pus.h.i.+ng forward its boundaries. At five o'clock the long line of blackened miners which is formed at the foot of the hoisting-shaft begins to leave the mine; and by six o'clock, with the exception of a few inspectors and fire-bosses, the mine is deserted.

The night-s.h.i.+ft began at eight, and it was as though night had suddenly been hastened forward, to step from the soft evening twilight on the hoist, and, in a brief second, leave behind the world and the day and plunge back into the darkness of the mine.

We were walking up the track from the mine-bottom toward six west-south--Billy Wild, Pat Davis, two track-repairers, and I. As we turned the corner by the run-around, there came suddenly from far off in the thick stillness a faint tremor and a strong current of air. The 'shooters' were at work. For a quarter of a mile we walked on, stopping every once in a while to listen to the far-off 'boom' of the blasts that came through the long tunnels, faint and distant, as though m.u.f.fled by many folds of heavy cloth. We pushed open the big trappers' door just beyond where First and Second Right turn off from the main entry, and came into the faint yellow glow of a single electric lamp that hung from the low beamed roof.

Beside the track, in a black niche cut in the wall of coal, two men were working. A safe twenty feet from them their lighted pit-lamps flared where they were hung by the hooks from one of the props. Round, black cans of powder tumbled together in the back of the alcove, a pile of empty paper tubes and great spools of thick, white fuse lay beside them.

We sat down on the edge of the track, at a safe distance from the open powder, and watched them as they blew open the long, white tubes and with a battered funnel poured in the coa.r.s.e grains of powder, until the smooth, round cartridge was filled, a yard or two of white fuse hanging from its end. In fifteen minutes they had finished, and one of the men gathered in his arms the pile of completed cartridges and joined us in the main entry.

A few minutes later, as we neared the heading, a sudden singing 'boom'

came down strongly against the air-current and bent back the flames in our pit-lamps. Far off in the blackness ahead, a point of light marked the direction of the tunnel; another appeared. Suddenly, from the thick silence, came the shrill whine of the air-drills. A couple of lamps, like yellow tongues of flame, shone dimly in the head of the tunnel, and the air grew thick with a flurry of fine coal-dust. Then, below the bobbing lights appeared the bodies of two men, stripped to the waist, the black coating of dust that covered them moist with gleaming streaks of sweat.

'How many holes have you drilled?' yelled Wild, his voice drowned by the scream of the long air-drill as the writhing bit tore into the coal.

There was a final convulsive grind as the last inch of the six-foot drill sank home, then the sudden familiar absence of sound save for the hiss of escaping air.

'All done here.'

Slowly the two men pulled the long screw blade from the black breast of the coal, the air-hose writhing like a wounded snake about their ankles.

The driller who had spoken wiped his sweaty face with his hands, his eyes blinking with the dust. He picked up his greasy coat from beside the track and wrapped it around his wet shoulders.

'Look out for the gas!' he shouted. 'There is a bit here, up high.'

He raised his lamp slowly to the jagged roof. A quick blue flame suddenly expanded from the lamp and puffed down at him as he took away his hand.

In the black end of the tunnel six small holes, each an inch and a half in diameter and six feet deep, invisible in the darkness and against the blackness of the coal, marked where the blasts were to be placed. On the level floor, stretching from one wall of the entry to the other, the undercut had been ground out with the chain-machines by the machine-men during the afternoon; and as soon as the blasts were in and the fuses lighted, the sudden wrench of these charges would tear down a solid block of coal six feet deep by the height and depth of the entry, to fall crushed and broken into the sump-cut, ready for the loaders on the following morning.

Selecting and examining each cartridge, the shooters charged the drill-holes. Two cartridges of black powder, tamped in with a long copper-headed rod; then dummies of clay for wads, leaving hanging like a great white cord from each charged drill-hole a yard of the long, white fuse.