The History of Sumatra Part 18

According to this they begin to dispose on the plate the larger compartments of the foliage, for which they use plain flat wire of a larger size, and fill them up with the leaves before mentioned. To fix their work they employ a glutinous substance made of the small red pea with a black spot before mentioned, ground to a pulp on a rough stone.

This pulp they place on a young coconut about the size of a walnut, the top and bottom being cut off. I at first imagined that caprice alone might have directed them to the use of the coconut for this purpose; but I have since reflected on the probability of the juice of the young fruit being necessary to keep the pulp moist, which would otherwise speedily become dry and unfit for the work. After the leaves have been all placed in order and stuck on, bit by bit, a solder is prepared of gold filings and borax, moistened with water, which they strew or daub over the plate with a feather, and then putting it in the fire for a short time the whole becomes united. This kind of work on a gold plate they call karrang papan: when the work is open, they call it karrang trus. In executing the latter the foliage is laid out on a card, or soft kind of wood covered with paper, and stuck on, as before described, with the paste of the red seed; and the work, when finished, being strewed over with their solder, is put into the fire, when, the card or soft wood burning away, the gold remains connected. The greatest skill and attention is required in this operation as the work is often made to run by remaining too long or in too hot a fire. If the piece be large they solder it at several times.

When the work is finished they give it that fine high colour they so much admire by an operation which they term sapoh. This consists in mixing nitre, common salt, and alum, reduced to powder and moistened, laying the composition on the filigree and keeping it over a moderate fire until it dissolves and becomes yellow. In this situation the piece is kept for a longer or shorter time according to the intensity of colour they wish the gold to receive. It is then thrown into water and cleansed. In the manufacture of baju b.u.t.tons they first make the lower part flat, and, having a mould formed of a piece of buffalo's horn, indented to several sizes, each like one half of a bullet mould, they lay their work over one of these holes, and with a horn punch they press it into the form of the b.u.t.ton. After this they complete the upper part. The manner of making the little b.a.l.l.s with which their works are sometimes ornamented is as follows. They take a piece of charcoal, and, having cut it flat and smooth, they make in it a small hole, which they fill with gold dust, and this melted in the fire becomes a little ball. They are very inexpert at finis.h.i.+ng and polis.h.i.+ng the plain parts, hinges, screws, and the like, being in this as much excelled by the European artists as these fall short of them in the fineness and minuteness of the foliage. The Chinese also make filigree, mostly of silver, which looks elegant, but wants likewise the extraordinary delicacy of the Malayan work. The price of the workmans.h.i.+p depends upon the difficulty or novelty of the pattern. In some articles of usual demand it does not exceed one-third of the value of the gold; but, in matters of fancy, it is generally equal to it. The manufacture is not now (1780) held in very high estimation in England, where costliness is not so much the object of luxury as variety; but, in the revolution of taste, it may probably be again sought after and admired as fas.h.i.+onable.

IRON MANUFACTURES.

But little skill is shown amongst the country people in forging iron.

They make nails however, though not much used by them in building, wooden pins being generally subst.i.tuted; also various kinds of tools, as the prang or bill, the banchi, rembe, billiong, and papatil, which are different species of adzes, the kapak or axe, and the pungkur or hoe.

Their fire is made with charcoal; the fossil coal which the country produces being rarely, if ever, employed, except by the Europeans; and not by them of late years, on the complaint of its burning away too quickly: yet the report made of it in 1719 was that it gave a surer heat than the coal from England. The bed of it (described rather as a large rock above ground) lies four days' journey up Bencoolen River, from whence quant.i.ties are washed down by the floods. The quality of coal is rarely good near the surface. Their bellows are thus constructed: two bamboos, of about four inches diameter and five feet in length, stand perpendicularly near the fire, open at the upper end and stopped below.

About an inch or two from the bottom a small joint of bamboo is inserted into each, which serve as nozzles, pointing to, and meeting at, the fire.

To produce a stream of air bunches of feathers or other soft substance, being fastened to long handles, are worked up and down in the upright tubes, like the piston of a pump. These, when pushed downwards, force the air through the small horizontal tubes, and, by raising and sinking each alternately, a continual current or blast is kept up; for which purpose a boy is usually placed on a high seat or stand. I cannot retrain from remarking that the description of the bellows used in Madagascar, as given by Sonnerat, Volume 2 page 60, so entirely corresponds with this that the one might almost pa.s.s for a copy of the other.

CARPENTER'S WORK.

The progress they have made in carpenter's work has been already pointed out, where there buildings were described.

TOOLS.

They are ignorant of the use of the saw, excepting where we have introduced it among them. Trees are felled by chopping at the stems, and in procuring boards they are confined to those the direction of whose grain or other qualities admit of their being easily split asunder. In this respect the species called maranti and marakuli have the preference.

The tree, being stripped of its branches and its bark, is cut to the length required, and by the help of wedges split into boards. These being of irregular thickness are usually dubbed upon the spot. The tool used for this purpose is the rembe, a kind of adze. Most of their smaller work, and particularly on the bamboo, is performed with the papatil, which resembles in shape as much as in name the patupatu of the New Zealanders, but has the vast superiority of being made of iron. The blade, which is fastened to the handle with a nice and curious kind of rattan-work, is so contrived as to turn in it, and by that means can be employed either as an adze or small hatchet. Their houses are generally built with the a.s.sistance of this simple instrument alone. The billiong is no other than a large papatil, with a handle of two or three feet in length, turning, like that, in its socket.

CEMENTS.

The chief cement they employ for small work is the curd of buffalomilk, called prakat. It is to be observed that b.u.t.ter is made (for the use of Europeans only; the words used by the Malays, for b.u.t.ter and cheese, monteiga and queijo, being pure Portuguese) not as with us, by churning, but by letting the milk stand till the b.u.t.ter forms of itself on the top.

It is then taken off with a spoon, stirred about with the same in a flat vessel, and well washed in two or three waters. The thick sour milk left at the bottom, when the b.u.t.ter or cream is removed, is the curd here meant. This must be well squeezed, formed into cakes, and left to dry, when it will grow nearly as hard as flint. For use you must sc.r.a.pe some of it off, mix it with quick lime, and moisten it with milk. I think there is no stronger cement in the world, and it is found to hold, particularly in a hot and damp climate, much better than glue; proving also effectual in mending chinaware. The viscous juice of the saga-pea (abrus) is likewise used in the country as a cement.

INK.

Ink is made by mixing lamp-black with the white of egg. To procure the former they suspend over a burning lamp an earthen pot, the bottom of which is moistened, in order to make the soot adhere to it.

DESIGNING.

Painting and drawing they are quite strangers to. In carving, both in wood and ivory, they are curious and fanciful, but their designs are always grotesque and out of nature. The handles of the krises are the most common subjects of their ingenuity in this art, which usually exhibit the head and beak of a bird, with the folded arms of a human creature, not unlike the representation of one of the Egyptian deities.

In cane and basketwork they are particularly neat and expert; as well as in mats, of which some kinds are much prized for their extreme fineness and ornamental borders.

LOOMS.

Silk and cotton cloths, of varied colours, manufactured by themselves, are worn by the natives in all parts of the country; especially by the women. Some of their work is very fine, and the patterns prettily fancied. Their loom or apparatus for weaving (tunun) is extremely defective, and renders their progress tedious. One end of the warp being made fast to a frame, the whole is kept tight, and the web stretched out by means of a species of yoke, which is fastened behind the body, when the person weaving sits down. Every second of the longitudinal threads, or warp, pa.s.ses separately through a set of reeds, like the teeth of a comb, and the alternate ones through another set. These cross each other, up and down, to admit the woof, not from the extremities, as in our looms, nor effected by the feet, but by turning edgeways two flat sticks which pa.s.s between them. The shuttle (turak) is a hollow reed about sixteen inches long, generally ornamented on the outside, and closed at one end, having in it a small bit of stick, on which is rolled the woof or shoot. The silk cloths have usually a gold head. They use sometimes another kind of loom, still more simple than this, being no more than a frame in which the warp is fixed, and the woof darned with a long small-pointed shuttle. For spinning the cotton they make use of a machine very like ours. The women are expert at embroidery, the gold and silver thread for which is procured from China, as well as their needles. For common work their thread is the pulas before mentioned, or else filaments of the pisang (musa).

EARTHENWARE.

Different kinds of earthenware, I have elsewhere observed, are manufactured in the island.

PERFUMES.

They have a practice of perfuming their hair with oil of benzoin, which they distil themselves from the gum by a process doubtless of their own invention. In procuring it a priuk, or earthen rice-pot, covered close, is used for a retort. A small bamboo is inserted in the side of the vessel, and well luted with clay and ashes, from which the oil drops as it comes over. Along with the benzoin they put into the retort a mixture of sugar-cane and other articles that contribute little or nothing to the quant.i.ty or quality of the distillation; but no liquid is added. This oil is valued among them at a high price, and can only be used by the superior rank of people.

OIL.

The oil in general use is that of the coconut, which is procured in the following manner. The fleshy part being sc.r.a.ped out of the nut, which for this use must be old, is exposed for some time to the heat of the sun. It is then put into a mat bag and placed in the press (kampahan) between two sloping timbers, which are fixed together in a socket in the lower part of the frame, and forced towards each other by wedges in a groove at top, compressing by this means the pulp of the nut, which yields an oil that falls into a trough made for its reception below. In the farther parts of the country this oil also, owing to the scarcity of coconuts, is dear; and not so much used for burning as that from other vegetables, and the dammar or rosin, which is always at hand.

TORCHES.

When travelling at night they make use of torches or links, called suluh, the common sort of which are nothing more than dried bamboos of a convenient length, beaten at the joints till split in every part, without the addition of any resinous or other inflammable substance. A superior kind is made by filling with dammar a young bamboo, about a cubit long, well dried, and having the outer skin taken off.

These torches are carried with a view, chiefly, to frighten away the tigers, which are alarmed at the appearance of fire; and for the same reason it is common to make a blaze with wood in different parts round their villages. The tigers prove to the inhabitants, both in their journeys and even their domestic occupations, most fatal and destructive enemies. The number of people annually slain by these rapacious tyrants of the woods is almost incredible. I have known instances of whole villages being depopulated by them. Yet, from a superst.i.tious prejudice, it is with difficulty they are prevailed upon, by a large reward which the India Company offers, to use methods of destroying them till they have sustained some particular injury in their own family or kindred, and their ideas of fatalism contribute to render them insensible to the risk.

TIGER-TRAPS.

Their traps, of which they can make variety, are very ingeniously contrived. Sometimes they are in the nature of strong cages, with falling doors, into which the beast is enticed by a goat or dog enclosed as a bait; sometimes they manage that a large timber shall fall, in a groove, across his back; he is noosed about the loins with strong rattans, or he is led to ascend a plank, nearly balanced, which, turning when he is past the centre, lets him fall upon sharp stakes prepared below. Instances have occurred of a tiger being caught by one of the former modes, which had many marks in his body of the partial success of this last expedient.

The escapes, at times, made from them by the natives are surprising, but these accounts in general carry too romantic an air to admit of being repeated as facts. The size and strength of the species which prevails on this island are prodigious. They are said to break with a stroke of their forepaw the leg of a horse or a buffalo; and the largest prey they kill is without difficulty dragged by them into the woods. This they usually perform on the second night, being supposed, on the first, to gratify themselves with sucking the blood only. Time is by this delay afforded to prepare for their destruction; and to the methods already enumerated, beside shooting them, I should add that of placing a vessel of water, strongly impregnated with a.r.s.enic, near the carcase, which is fastened to a tree to prevent its being carried off: The tiger having satiated himself with the flesh, is prompted to a.s.suage his thirst with the tempting liquor at hand, and perishes in the indulgence. Their chief subsistence is most probably the unfortunate monkeys with which the woods abound. They are described as alluring them to their fate, by a fascinating power, similar to what has been supposed of the snake, and I am not incredulous enough to treat the idea with contempt, having myself observed that when an alligator, in a river, comes under an overhanging bough of a tree, the monkeys, in a state of alarm and distraction, crowd to the extremity, and, chattering and trembling, approach nearer and nearer to the amphibious monster that waits to devour them as they drop, which their fright and number renders almost unavoidable. These alligators likewise occasion the loss of many inhabitants, frequently destroying the people as they bathe in the river, according to their regular custom, and which the perpetual evidence of the risk attending it cannot deter them from. A superst.i.tious idea of their sanct.i.ty also (or, perhaps, of consanguinity, as related in the journal of the Endeavour's voyage) preserves these destructive animals from molestation, although, with a hook of sufficient strength, they may be taken without much difficulty. A musket-ball appears to have no effect upon their impenetrable hides.

FIs.h.i.+NG.

Besides the common methods of taking fish, of which the seas that wash the coasts of Sumatra afford an extraordinary variety and abundance, the natives employ a mode, unpractised, I apprehend, in any part of Europe.

They steep the root of a certain climbing plant, called tuba, of strong narcotic qualities, in the water where the fish are observed, which produces such an effect that they become intoxicated and to appearance dead, float on the surface of the water, and are taken with the hand.

This is generally made use of in the basins of water formed by the ledges of coral rock which, having no outlet, are left full when the tide has ebbed.* In the manufacture and employment of the casting-net they are particularly expert, and scarcely a family near the sea-coast is without one. To supply this demand great quant.i.ties of the pulas twine are brought down from the hill-country to be there worked up; and in this article we have an opportunity of observing the effect of that conformation which renders the handiwork of orientals (una.s.sisted by machinery) so much more delicate than that of the western people. Mr.

Crisp possessed a net of silk, made in the country behind Padang, the meshes of which were no wider than a small fingernail, that opened sixteen feet in diameter. With such they are said to catch small fish in the extensive lake situated on the borders of Menangkabau.

(*Footnote. In Captain Cook's second voyage is a plate representing a plant used for the same purpose at Otaheite, which is the exact delineation of one whose appearance I was well acquainted with in Sumatra, and which abounds in many parts of the sea-beach, but which is a different plant from the tuba-akar, but may be another kind, named tuba-biji. In South America also, we are informed, the inhabitants procure fish after this extraordinary manner, employing three different kinds of plants; but whether any of them be the same with that of Otaheite or Sumatra I am ignorant. I have lately been informed that this practice is not unknown in England, but has been prohibited. It is termed foxing: the drug made use of was the Coculus indicus.)

BIRD-CATCHING.

Birds, particularly the plover (cheruling) and quails (puyu) are caught by snares or springs laid for them in the gra.s.s. These are of iju, which resembles horsehair, many fathoms in length, and disposed in such a manner as to entangle their feet; for which purpose they are gently driven towards the snares. In some parts of the country they make use of clasp-nets. I never observed a Sumatran to fire a shot at a bird, though many of them, as well as the more eastern people, have a remarkably fine aim; but the mode of letting off the matchlocks, which are the pieces most habitual to them, precludes the possibility of shooting flying.

GUNPOWDER.

Gunpowder is manufactured in various parts of the island, but less in the southern provinces than amongst the people of Menangkabau, the Battas, and Achinese, whose frequent wars demand large supplies. It appears however, by an agreement upon record, formed in 1728, that the inhabitants of Anak-sungei were restricted from the manufacture, which they are stated to have carried to a considerable extent. It is made, as with us, of proportions of charcoal, sulphur, and nitre, but the composition is very imperfectly granulated, being often hastily prepared in small quant.i.ties for immediate use. The last article, though found in the greatest quant.i.ty in the saltpetre-caves before spoken of, is most commonly procured from goat's dung, which is always to be had in plenty.

SUGAR.

Sugar (as has already been observed) is commonly made for domestic use from the juice of a species of palm, boiled till a consistence is formed, but scarcely at all granulated, being little more than a thick syrup.

This spread upon leaves to dry, made into cakes, and afterwards folded up in a peculiar vegetable substance called upih, which is the sheath that envelopes the branch of the pinang tree where it is inserted in the stem.

In this state it is called jaggri, and, beside its ordinary uses as sugar, it is mixed with chunam in making cement for buildings, and that exquisite plaster for walls which, on the coast of Coromandel, equals Parian marble in whiteness and polish. But in many parts of the island sugar is also made from the sugar-cane. The rollers of the mill used for this purpose are worked by the endless screw instead of cogs, and are turned with the hand by means of a bar pa.s.sing through one of the rollers which is higher than the other. As an article of traffic amongst the natives it is not considerable, nor have they the art of distilling arrack, the basis of which is mola.s.ses, along with the juice of the anau or of the coconut palm in a state of fermentation. Both however are manufactured by Europeans.*

(*Footnote. Many attempts have been made by the English to bring to perfection the manufacture of sugar and arrack from the canes; but the expenses, particularly of the slaves, were always found to exceed the advantages. Within these few years (about 1777) that the plantations and works were committed to the management of Mr. Henry Botham, it has manifestly appeared that the end is to be obtained by employing the Chinese in the works of the field and allowing them a proportion of the produce for their labour. The manufacture had arrived at considerable perfection when the breaking out of war gave a check to its progress; but the path is pointed out, and it may be worth pursuing. The sums of money thrown into Batavia for arrack and sugar have been immense.)

SALT.

Salt is here, as in most other countries, an article of general consumption. The demand for it is mostly supplied by cargoes imported, but they also manufacture it themselves. The method is tedious. They kindle a fire close to the sea-beach, and gradually pour upon it sea water. When this has been continued for a certain time, the water evaporating, and the salt being precipitated among the ashes, they gather these in baskets, or in funnels made of the bark or leaves of trees, and again pour seawater on them till the particles of salt are well separated, and pa.s.s with the water into a vessel placed below to receive them. This water, now strongly impregnated, is boiled till the salt adheres in a thick crust to the bottom and sides of the vessel. In burning a square fathom of firewood a skilful person procures about five gallons of salt. What is thus made has so considerable a mixture of the salt of the wood that it soon dissolves, and cannot be carried far into the country. The coa.r.s.est grain is preferred.

ART OF MEDICINE.

The art of medicine among the Sumatrans consists almost entirely in the application of simples, in the virtues of which they are well skilled.

Every old man and woman is a physician, and their rewards depend upon their success; but they generally procure a small sum in advance under the pretext of purchasing charms.* The mode of practice is either by administering the juices of certain trees and herbs inwardly, or by applying outwardly a poultice of leaves chopped small upon the breast or part affected, renewing it as soon as it becomes dry. For internal pains they rub oil on a large leaf of a stimulant quality, and, heating it before the fire, clap it on the body of the patient as a blister, which produces very powerful effects. Bleeding they never use, but the people of the neighbouring island of Nias are famous for their skill in cupping, which they practise in a manner peculiar to themselves.

(*Footnote. Charms are there hung about the necks of children, as in Europe, and also worn by persons whose situations expose them to risk.

They are long narrow scrolls of paper, filled with incoherent sc.r.a.ps of verse, which are separated from each other by a variety of fanciful drawings. A charm against an ague I once accidentally met with, which from circ.u.mstances I conclude to be a translation of such as are employed by the Portuguese Christians in India. Though not properly belonging to my subject, I present it to the reader. "(Sign of the cross). When Christ saw the cross he trembled and shaked; and they said unto him hast thou an ague? and he said unto them, I have neither ague nor fever; and whosoever bears these words, either in writing or in mind, shall never be troubled with ague or fever. So help thy servants, O Lord, who put their trust in thee!" From the many folds that appear in the original I have reason to apprehend that it had been worn, and by some Englishmen, whom frequent sickness and the fond love of life had rendered weak and superst.i.tious enough to try the effects of this barbarous and ridiculous quackery.)

FEVERS.